Whatever the cause, Washington state bridge collapse points to bigger problems

Older infrastructures often not up to today's standards


Share with others:


Print Email Read Later

WASHINGTON -- The collapse of an interstate highway bridge in Washington state brings new attention to the limits of the nation's infrastructure, especially older structures designed with little room for error and never intended to carry the number of cars and trucks they see today.

The 58-year-old Interstate 5 bridge over the Skagit River in Mount Vernon, Wash., was considered outdated, but not structurally deficient. While state police believe that an oversize truck hitting the bridge may have contributed to its collapse, a National Transportation Safety Board investigation will ultimately pinpoint the cause.

Bridge experts said the I-5 bridge shares a design feature with thousands of other bridges across the country that make them more vulnerable to failure. The bridge was fracture-critical, which means there is no redundancy in the structure; if one component fails, the whole bridge can collapse. It is a scenario that has happened before, and experts say it will happen again if older, obsolete bridges are not replaced or reinforced.

"This is a repetitive story that's going to play out again like a horrible nightmare," said New York construction lawyer Barry LePatner, who has identified nearly 8,000 of the most troublesome U.S. spans.

A 40-year-old interstate bridge in Minneapolis that collapsed into the Mississippi River in 2007 also had a fracture-critical design. Thirteen people were killed, and scores more were injured. No one was killed or seriously injured in Thursday's collapse. "It could have been a lot worse," said American Society of Civil Engineers executive director Pat Natale.

Another fracture-critical bridge over the Ohio River between Louisville, Ky., and New Albany, Ind., was closed for several months in 2011, after inspectors discovered a large hidden crack that could have proved disastrous. Engineers added reinforcement to the structure for a fraction of the replacement cost, and Mr. LePatner said a bridge such as the one on I-5 similarly could have been made stronger. "Government officials have failed to fund needed maintenance," he said, "and these bridges have long passed their intended lifespan."

The oldest parts of the Interstate Highway System are more than 50 years old and need repair and replacement just as states and the federal government confront shrinking funds to build and maintain infrastructure.

At a news conference Friday, Washington state Transportation Secretary Lynn Peterson said only the bridge section that collapsed would be rebuilt. Washington Gov. Jay Inslee said the repair would cost $15 million. Replacement could cost many times more. "Under current fiscal constraints, there's no intent to rebuild the entire bridge," Ms. Peterson said.

Washington state has much incentive to finish the repairs quickly. Interstate 5 is the primary highway corridor along the Pacific Coast, daily carrying an average of 71,000 vehicles, including 10,000 trucks, which will have to endure lengthy and costly detours until the bridge is repaired.

U.S. Transportation Secretary Ray LaHood announced Friday that $1 million in emergency federal funds would be available to help repair the bridge. But the bridge will reopen with the same narrow lanes and low clearances it always had; it predates the interstate system and was not constructed to federal standards for interstates.

Mr. Natale, the civil engineers society director, said it wouldn't be enough just to patch over the problem and move on. His group recently gave the nation's infrastructure a "D-plus," and he said improving it should start with aggressive upkeep.

"The problem is when we get into tight financial situations, we cut maintenance and inspections," he said. "When we find a condition like this, we need to act more quickly."

nation - Transportation

First Published May 25, 2013 4:00 AM


Advertisement
Advertisement
Advertisement

You have 2 remaining free articles this month

Try unlimited digital access

If you are an existing subscriber,
link your account for free access. Start here

You’ve reached the limit of free articles this month.

To continue unlimited reading

If you are an existing subscriber,
link your account for free access. Start here